NEW ARTICLES  HOT ARTICLES  TOP RATED  ADD AN ARTICLE  UPDATE AN ARTICLE  GET RATED 
  HOME     MY ACCOUNT     POWER SEARCH     REGISTER     SUPPORT     SUGGEST CATEGORY  

Commercial Printing Methods
8842 Computers > Hardware Mar 1, 2007 Touch Media Design Commercial Printing Methods What are my choices for printing my catalog? What are the different types of catalog printing and which ones are the best for my catalog? In this article I will go over several types of catalog printing to help you answer those questions.

Let?s start with the different types of presses that are used for printing catalogs.

Web Press: This is the most commonly used type of press for printing catalogs. It uses a roll of paper to make the catalog printing process faster. There are two types of web press. The Heat-Set Web Press and the Cold-Set Web Press.

Heat-Set Web Press: The heat-set web press has a built-in heating unit that dries the ink. This gives the press the ability to produce a high volume of catalogs quickly. Another advantage it has is It can handle printing your catalog on coated and high-gloss paper. A heat-set web press is also the best choice if your catalog needs to have high quality photographs and images.

Heat-set web presses are good for large catalog printing jobs or where the cost of setup is irrelevant. It is a huge press and takes a staff of people to set it up for one catalog printing job. This is where you run into setup fees from your printer. On a large run, say 10,000 copies or more, the setup fee when divided by the number of catalogs is not too bad. If you were to apply those same setup fees to a run of only 1000 copies, the cost per catalog printed might be out of your budget requirements.

Cold-Set Web Press: This type of web press does not have a heating unit. The ink must be air-dried. The cold-set web press is used with text stock paper where the ink will absorb into the paper of your catalog. It will not print on coated and glossy paper. In addition to that, the photos and images for your catalog will not be quite as sharp as those printed on a heat-set web press.

However, if you are printing less than 10,000 catalogs or your primary needs are not the sharpness of the images, a cold-set web press might be the right choice for you. It will save you money over the heat-set method.

Sheet-Fed Press: Another good choice if you are not printing a high volume of catalogs is the sheet-fed press. The paper for your catalog is cut to size before the print run. One of the advantages a sheet-fed press has over the cold-set web press is that your images and photos will come out a much higher quality. Both are good for small runs, so if you are only going to print less than 10,000 catalogs and your artwork is important to you, the sheet-fed press might be the best way to go.

The sheet-fed press can also use various weights of paper, giving it another advantage over a cold-set web press. The downside is that sheet-fed presses run much slower. That is why they are usually only selected for a small run of catalogs or catalogs that require high quality graphics.

Digital Printing: This is much newer than the other methods described in this article, but it will become mainstream. This is where the images for printing your catalog are sent directly from the computer to the press. There is no film involved. All of the images are digital. This also eliminates the need for plates. Finding a printer for your catalog that uses this method might be difficult though since it has not been widely adopted yet.

The advantages of digital printing are fast-turnaround time and for producing high quality full color catalogs. The downside is that you may be limited in your choice of paper types.

Electrostatic printing: Only good for very short runs of catalog printing jobs. This is similar to photocopying documents in that it uses toner from a drum to thermally fuse your text and images to the paper.

Embossing: This catalog printing method uses a die your printer makes according to your design. It makes an impression or raises the image or letters onto the page.

Engraving: This is the catalog printing method that produces the highest quality images. You would only use this on the covers unless cost is not a factor. With engraved images, you can run your finger along the edge and fell that it has been indented or raised.

Gravure: This method of printing is used to produce a high volume of quality catalogs. It is much more expensive than other methods, but it is the best way to produce high quality catalogs.

Letterpress: This method of catalog printing goes back to the 15th century. It uses a rubber stamp like process. The images or text are raised on the stamp and ink is applied and the pages are stamped.

Offset lithography: This is a common catalog printing method with little setup time and one that is very cost effective. It?s also good for printing on textured paper. It uses less ink than other methods as well.

I hope this has been a helpful guide to the different printing methods you can choose for your catalog. Keep in mind that every printer you go to will not be able to offer you all of these methods. Each printer buys the equipment best suited to his or her business. So if you are set on a particular type of catalog printing you may have to shop around to find a printer who uses your method.

Content Provider: http://www.traffichelp4u.com

www.touchmediadesign.com - TOUCH MEDIA DESIGN is a full-service creative company specializing in assisting both online and offline businesses in web design, e-commerce, catalog design, graphic design, product photography, printing, and marketing.


Write a Review   Add to My Favorite   Refer it to Friend   Report Article  

Average Visitor Rating: 0.00 (out of 5)
Number of ratings: 0 Votes

Visitor Rating


Other links owned by this user
The following is by no means all of the rms that you may come across when dealing with your prinr. What we wand to do here is provide you with many of the most common rms so you can understand the catalog printing process betr. Many of these
Category:

There are many things that are important to catalog design. Your images must be sharp and appealing. Your text and even the font you use for the text is important. The cover page design and the design of your catalog?s pduct pages all play important
Category:

What are my choices for printing my catalog? What are the different types of catalog printing and which ones are the best for my catalog? In this article I will go over several types of catalog printing to help you answer those
Category:

Okay, by now you know that printing and distributing a catalog will help you sell your product. You have chosen how you want to design your catalog but you have some printing questions. In this article I will help you explore all of your options and
Category:

In this rticle I m going to give you some tips bout photogrphing your products for your ctlog. The imges you use in your ctlog re the most importnt fetures you will be deciding on. The imges sell your products. The text nd everything else
Category:

Other links at Computers > Hardware
No matter how many times you have used your printer without a problem in the world, it is a safe bet that the time when you need it most is the precise moment that the silly machine will start acting up. As you are frantically striking keys and clicking
Category:

How to upgrade computer system memory for Windows Vista Operating System.
Category:

Some inkjet cartridge clogs are very difficult to clear. When you run onto one of these you will need the most powerful methods available. This article gives some of the methods used by printer techs to clear these clogs.
Category:

If you choose the wrong printer you may be in for trouble.This articles gives you enough information to make a wise choice.
Category:

It is best to read reviews of popular computers before finally choosing the one to buy.
Category:




Site Sponsor
Directory Statistics

Articles: 68222
Categories: 501

Yahoo Entertainment
Valid XHTML 1.0 Transitional   Valid CSS